消石灰对细粒级铁精矿球团性能的影响

doi:10.13228/j.boyuan.issn0449-749x.20220744

Abstract
Figure/Table
References
Related Citation (3)

Download: PDF (3758 KB) HTML (1 KB)
Export: BibTeX | EndNote (RIS)

Abstract The pelletization of fine-grained iron ore concentrates helps to increase the development and industrial application of low-grade deposits and stabilize and expand the domestic iron ore supply sources. The use of lime hydrate as a binder and flux for pellets is of great significance to the pellet production in terms of quality improvement and consumption reduction,energy saving and emission reduction.The effect of lime hydrate ratio on the quality and drying characteristics of fine iron ore concentrate green pellets and the strength of preheated roasted pellets is introduced for the first time. The test results show that the increase of lime hydrate ratio will improve the falling and compressive strength of fine iron ore concentrate green pellets. The results of fitting Weibull and Dincer model are basically consistent with the experimental results,and the model is more effective. The fitting results show that the drying rate of green pellets is jointly controlled by internal and external moisture diffusion,and the increase of drying temperature and drying air speed will lead to the drying temperature distribution of green pellets tends to be uneven,and the activation energy value of green pellets is 9 977.30 J/(mol·K),the strength of preheated pellets of fine-grained iron ore concentrate always increases with the increase of lime hydrate ratio,and the compressive strength of roasted pellets increases first and then decreases, reaching the maximum value of 3 800 N at the ratio of 4%. The pellets of pellets prepared from lime hydrate and fine-grained iron ore concentrate with 4%-6% lime hydrate are suitable to obtain pellets with the strength of green pellets and preheated roasted pellets that meet the industrial requirements,the study on the drying characteristics of raw pellets prepared from lime hydrate and fine-grained iron ore concentrate can provide theoretical support to reduce the drying breakage of raw pellets through the selection of drying equipment and optimization of drying conditions.

Key words： lime hydrate fine-grained iron ore concentrate green pellet quality drying characteristics preheating and roasting

Received: 04 December 2022

	Service

	E-mail this article
	Add to my bookshelf
	Add to citation manager
	E-mail Alert
	RSS
	Articles by authors
	CONG Jun-qiang
	WEN Bao-liang
	LI Jia-xin
	ZHANG Xiao-ping
	YANG Jia-long

Cite this article:

CONG Jun-qiang,WEN Bao-liang,LI Jia-xin等. Effect of lime hydrate on pellet properties of fine-grained iron ore concentrates[J]. Iron and Steel, 2023, 58(5): 20-30.

URL:

http://www.chinamet.cn/Jweb_gt/EN/10.13228/j.boyuan.issn0449-749x.20220744 OR http://www.chinamet.cn/Jweb_gt/EN/Y2023/V58/I5/20

[1] 张福明. 炼铁系统低碳技术发展前景与途径[J]. 钢铁,2022,57(9):11.(ZHANG Fu-ming. Development prospects and methods on low-carbon technology in ironmaking system[J]. Iron and Steel,2022,57(9):11.)
[2] 廖军平,陈昭尧. SG带式焙烧机镁质球团矿的生产应用[J]. 中国冶金,2021,31(10):51.(LIAO Jun-ping,CHEN Zhao-yao. Production and application of SG belt roaster magnesium pellet[J]. China Metallurgy,2021,31(10):51.)
[3] 徐萌,王伟,孙健,等. 超大型高炉高球比低碳冶炼技术应用[J]. 中国冶金,2021,31(9):98.(XU Meng,WANG Wei,SUN Jian,et al. Application on low carbon smelting technology for feeding large percentage of pellets into super-large BF[J] China Metallurgy,2021,31(9):98.)
[4] 王新东,金永龙. 高炉使用高比例球团的战略思考与球团生产的试验研究[J]. 钢铁,2021,56(5):7.(WANG Xin-dong,JIN Yong-long. Strategy analysis and testing study of high ratio of pellet utilized in blast furnace[J]. Iron and Steel,2021,56(5):7.)
[5] 路明,陈小燕,王兴锋,等. 钙质添加剂对碱性球团性能的影响[J]. 冶金能源,2022,41(2):19.(LU Ming,CHEN Xiao-yan,WANG Xing-feng,et al. Effect of calcium additives on the performance of calcium fluxed iron ore pellets[J]. Energy for Metallurgical Industry,2022,41(2):19.)
[6] Mousa E A,Babich A,Senk D. A novel approach for utilization of ultra-fines iron ore in sintering process[J]. Steel Research International,2015,86(11):1350.
[7] 于洪军,路明,王兴锋,等. 铁矿粉粒度组成对球团矿性能影响的研究进展[J]. 冶金能源,2022,41(1):21.(YU Hong-jun,LU Ming,WANG Xing-feng,et al. Research progress on the effect of iron fine particle size on pellet properties[J]. Energy for Metallurgical Industry,2022,41(1):21.)
[8] 贺淑珍,冯焕林,甘敏,等. 超细铁精矿粉特性对烧结的影响[J]. 钢铁研究学报,2015,27(4):6.(HE Shu-zhen,FENG Huan-lin,GAN Min,et al. Effects of characters of ultra fine iron ore concentrate on sinter[J]. Journal of Iron and Steel Research,2015,27(4):6.)
[9] 周明顺,王义栋,赵东明,等. 高配比磁铁精矿烧结技术的研究进展[J]. 钢铁,2020,55(5):9.(ZHOU Ming-shun,WANG Yi-dong,ZHAO Dong-ming,et al. Development on sintering technologies with high proportion of magnetite concentrates[J]. Iron and Steel,2020,55(5):9.)
[10] 贺淑珍,冯焕林,甘晓靳,等. 微细精矿比例对烧结的影响及强化技术[J]. 钢铁研究学报,2016,28(9):10.(HE Shu-zhen,FENG Huan-lin,GAN Xiao-jin,et al. Effect of ultra fine ore on sintering and strengthening measures[J]. Journal of Iron and Steel Research,2016,28(9):10.)
[11] Pal J,Ghorai S,Venugopalan T. Effect of high Blaine iron ore fines in hematite ore pelletization for blast furnace[J]. Mineral Processing and Extractive Metallurgy,2020,129(3):299.
[12] 朱德庆,徐梦杰,潘建,等. 改善超细铁精矿成球性能的实验研究[J]. 钢铁研究学报,2017,29(9):704.(ZHU De-qing,XU Meng-jie,PAN Jian,et al. Experimental research to improve ballability of ultrafine concentrate[J]. Journal of Iron and Steel Research,2017,29(9):704.)
[13] 温宝良,张晓萍,刘德楼,等. 含硼磁铁矿对超细粒级磁铁矿球团性能的影响[J]. 钢铁,2022,57(11):33.(WEN Bao-liang,ZHANG Xiao-ping,LIU De-lou,et al. Effect of boron-containing magnetite on properties of ultrafine-grained magnetite pellets[J]. Iron and Steel,2022,57(11):33.)
[14] 朱德庆,周冰致,王召元,等. 西澳超细粒磁铁精矿特性及其对球团焙烧性能的影响[J]. 烧结球团,2016,41(6):38.(ZHU De-qing,ZHOU Bing-zhi,WANG Zhao-yuan,et al. Characteristics of Western Australia Ultrafine(WAU) magnetite concentrates and their influence on pellet roasting performance[J]. Sintering and Pelletizing,2016,41(6):38.)
[15] 范晓慧,田志远,甘敏,等. 细粒磁铁精矿球团孔隙结构的优化研究[J]. 矿冶工程,2018,38(1):71.(FAN Xiao-hui,TIAN Zhi-yuan,GAN Min,et al. Optimization of pore structure of fine-grained magnetite concentrate pellets[J]. Mining and Metallurgical Engineering,2018,38(1):71.)
[16] 易毅辉,张津,张鑫,等. 煤基胶体复合黏结剂制备钒钛磁铁矿球团的研究[J]. 中国矿业大学学报,2022,51(3):445.(YI Yi-hui,ZHANG Jin,ZHANG Xin,et al. Study of preparation of vanadium-titanium magnetite pellets using coal-based colloidal composite binder[J]. Journal of China University of Mining and Technology,2022,51(3):445.)
[17] Prusti P,Barik K,Dash N,et al. Effect of limestone and dolomite flux on the quality of pellets using high LOI iron ore[J]. Powder Technology,2021,379:154.
[18] 范建军,郭宇峰,臧龙,等. 碱度对细粒级铁矿粉球团性能的影响[J]. 钢铁研究学报,2019,31(5):440.(FAN Jian-jun,GUO Yu-feng,ZANG Long,et al. Effect of basicity on properties of pellets produced by ultra fine-sized iron concentrate[J]. Journal of Iron and Steel Research,2017,29(9):704.)
[19] Kawatra S K,Claremboux V. Iron ore pelletization:Part II. Inorganic binders[J]. Mineral Processing and Extractive Metallurgy Review,2021,43(7):813.
[20] FAN X,GAN M,JIANG T,et al. Influence of flux additives on iron ore oxidized pellets[J]. Journal of Central South University of Technology,2010,17(4):732.
[21] ZHU D,YU W,CHUN T,et al. Improving the pelletization of fluxed hematite pellets by hydrated lime[C]//2nd International Symposium on High-Temperature Metallurgical Processing. San Diego:2011 The Minerals, Metals and Materials Society,2011:27.
[22] 乔红梅,张建良,王耀祖,等. 国内外钙质碱性球团生产实践及发展趋势[J]. 钢铁研究学报,2021,33(10):1031.(QIAO Hong-mei,ZHANG Jian-liang,WANG Yao-zu,et al. Production practice and development trend of calcareous alkaline pellets around the world[J]. Journal of Iron and Steel Research,2021,33(10):1031.)
[23] ZHU D Q,WANG D,PAN J,et al. Utilization of hydrated lime as binder and fluxing agent for the production of high basicity magnesium fluxed pellets[J]. ISIJ International,2022,62(4):632.
[24] Eisele T C,Kawatra S K. A review of binders in iron ore pelletization[J]. Mineral Processing and Extractive Metallurgy Review,2003,24(1):1.
[25] Pal J,Arunkumar C,Rajshekhar Y,et al. Development on iron ore pelletization using calcined lime and MgO combined flux replacing limestone and bentonite[J]. ISIJ International,2014,54(10):2169.
[26] ZHANG H,LIU C,LU M,et al. Kinetic model research on drying characteristics of artificial magnetite green pellet[J]. Journal of Central South University,2021,28(1):89.
[27] Souza Pinto T C,Souza A S,Batista J,et al. Characterization and drying kinetics of iron ore pellet feed and sinter feed[J]. Drying Technology,2021,39(10):1359.
[28] Dincer I,Hussain M M. Development of a new Biot number and lag factor correlation for drying applications[J]. International Journal of Heat and Mass Transfer,2004,47(4):653.
[29] Ju H,Zhao S,Mujumdar A S,et al. Energy efficient improvements in hot air drying by controlling relative humidity based on Weibull and Bi-Di models[J]. Food and Bioproducts Processing,2018,111:20.
[30] Athayde M,Cota M,Covcevich M. Iron ore pellet drying assisted by microwave:A kinetic evaluation[J]. Mineral Processing and Extractive Metallurgy Review,2018,39(4):266.
[31] 姜涛. 铁矿造块学[M]. 长沙:中南大学出版社,2016.(JIANG Tao. Iron Ore Briquetting[M]. Changsha:Central South University Press,2016.)
[32] Rumpf H. The strength of granules and agglomerates[C]//Agglomeration-Proceedings of the First International Symposium on Agglomeration. Philadelphia:Society of Mining Engineers of AIME, Iron and Steel Society of AIME,1962:379.
[33] Eisele T C,Kawatra S K. A review of binders in iron ore pelletization[J]. Mineral Processing and Extractive Metallurgy Review,2003,24(1):1.
[34] 刘卫星,李杰,杨爱民,等. 碱度对镁质熔剂性球团矿强度的影响机理[J]. 钢铁,2021,56(1):28.(LIU Wei-xing,LI Jie,YANG Ai-min,et al. Influence mechanism of basicity on strength of magnesium fluxed pellets[J]. Iron and Steel,2021,56(1):28.)
[35] 张林林,付刚华,郭宇峰,等. 碱度对熔剂性球团生球性能的影响[J]. 钢铁,2019,54(5):5.(ZHANG Lin-lin,FU Gang-hua,GUO Yu-feng,et al. Effect of basicity on quality of green fluxed pellets[J]. Iron and Steel,2019,54(5):5.)
[36] Kawatra S K,Claremboux V. Iron ore pelletization:Part i. Fundamentals[J]. Mineral Processing and Extractive Metallurgy Review,2022,43(4):529.