|
|
Interaction effect between lump and sinter under condition of oxygen blast furnace |
CHEN Long,XUE Qing-guo,GUO Wen-tao,SHE Xue-feng,WANG Jing-song |
(State Key Laboratory of Advanced Metallurgy,University of Science and Technology Beijing,Beijing 100083, China) |
|
|
Abstract This research describes the influence of oxygen blast furnace (OBF) atmosphere and the traditional blast furnace (T-BF) atmosphere on the softening and melting behavior of lump burden and lump-sinter mixed burden using the softening and melting test. The results indicate that in the OBF atmosphere, the development of reduction degree increased the quantity of the iron phase in the burden particle, and decreased the quantity of slag phase with low melting temperature, so the softening and melting properties of lump ore are developed compared to that in the T-BF case. In addition, through the analysis on relevant data of softening and melting process and on the microstructure of burden particles, it is revealed that the interaction effect also happened at the interface between lump and sinter particles in the OBF case. Because of the increase of iron phase amount and the reduction of slag phase amount, the contact of different slag is delayed, and the amount of contacted slag is reduced. Therefore, comparing with the T-BF case, the temperature on which the interaction behavior happened in the OBF case is raised, and the effect intensity is weakened.
|
Received: 12 March 2015
Published: 27 January 2016
|
|
|
|
|
[1] |
Nandy B, Chandra S, Bhattacharjee D, et.al. Assessment of blast furnace behavior through softening-melting test[J].Ironmaking & Steelmaking, 2006, 33(2):111-119
|
[1] |
Nandy B, Chandra S, Bhattacharjee D, et.al. Assessment of blast furnace behavior through softening-melting test[J].Ironmaking & Steelmaking, 2006, 33(2):111-119
|
[2] |
P.L. Hooev, J. Sterneland, M. Hakkin, et.al. Evaluation of High Temperature Properties of Blast Furnace Burden [C]. //1 st International Meeting on Ironmaking, Belo Horizonte, Brazil, 2001: 160
|
[2] |
P.L. Hooev, J. Sterneland, M. Hakkin, et.al. Evaluation of High Temperature Properties of Blast Furnace Burden [C]. //1 st International Meeting on Ironmaking, Belo Horizonte, Brazil, 2001: 160
|
[3] |
Nishimura T, Higuchi K, Naito M, et al.Evaluation of Softening,Shrinking and Melting Reduction Behavior of Raw Materials for Blast Furnace[J].ISIJ International, 2011, 51(8):1316-1321
|
[3] |
Nishimura T, Higuchi K, Naito M, et al.Evaluation of Softening,Shrinking and Melting Reduction Behavior of Raw Materials for Blast Furnace[J].ISIJ International, 2011, 51(8):1316-1321
|
[4] |
韩毅华, 王静松, 李燕珍, 等.炉顶煤气循环—氧气鼓风高炉综合数学模型[J].北京科技大学学报, 2011, 33(10):1280-1286
|
[4] |
韩毅华, 王静松, 李燕珍, 等.炉顶煤气循环—氧气鼓风高炉综合数学模型[J].北京科技大学学报, 2011, 33(10):1280-1286
|
[5] |
吴胜利, 许海法, 汪国俊, 等.现代高炉合理使用天然块矿的基础研究[J][J].北京科技大学学报, 2007, 29(03):320-325
|
[5] |
吴胜利, 许海法, 汪国俊, 等.现代高炉合理使用天然块矿的基础研究[J][J].北京科技大学学报, 2007, 29(03):320-325
|
[6] |
王海涛, 李光辉, 范晓慧, 等.几种高炉炉料冶金性能的对比研究[J].钢铁, 2006, 41(01):23-28
|
[6] |
王海涛, 李光辉, 范晓慧, 等.几种高炉炉料冶金性能的对比研究[J].钢铁, 2006, 41(01):23-28
|
[7] |
Chin Eng LOO, Matthews L T, et al.Lump Ore and Sinter Behaviour during Softening and Melting[J].ISIJ International, 2011, 51(6):930-938
|
[7] |
Chin Eng LOO, Matthews L T, et al.Lump Ore and Sinter Behaviour during Softening and Melting[J].ISIJ International, 2011, 51(6):930-938
|
[8] |
乔哲, 张华杰, 王静松, 等.氧气高炉条件下含铁炉料的程序还原行为实验研究[J].[J].太原理工大学学报, 2014, 30(01):25-28
|
[8] |
乔哲, 张华杰, 王静松, 等.氧气高炉条件下含铁炉料的程序还原行为实验研究[J].[J].太原理工大学学报, 2014, 30(01):25-28
|
[9] |
An X W, Wang J S, Lan R Z.Softening and Melting Behavior of Mixed Burden for Oxygen Blast Furnace[J].Journal of Iron and Steel Research, 2013, 20(5):11-19
|
[9] |
An X W, Wang J S, Lan R Z.Softening and Melting Behavior of Mixed Burden for Oxygen Blast Furnace[J].Journal of Iron and Steel Research, 2013, 20(5):11-19
|
[10] |
Paulo F, Richard J.Blast furnace burden softening and melting phenomena: Part IPellet bulk interaction observation[J].Metallurgical and Materials Transactions B, 2004, 35(5):829-838
|
[10] |
Paulo F, Richard J.Blast furnace burden softening and melting phenomena: Part IPellet bulk interaction observation[J].Metallurgical and Materials Transactions B, 2004, 35(5):829-838
|
[11] |
Paulo F, Richard J.Blast furnace burden softening and melting phenomena: Part IIEvolution of the structure of the pellets[J].Metallurgical and Materials Transactions B, 2005, 36(5):583-590
|
[11] |
Paulo F, Richard J.Blast furnace burden softening and melting phenomena: Part IIEvolution of the structure of the pellets[J].Metallurgical and Materials Transactions B, 2005, 36(5):583-590
|
[12] |
Inayoshi A, Hayashi S.Influence of Hydrogen on Reaction Behavior of Sinter Under a Blast Furnace Simulated Condition[J].Tetsu to Hagane, 2010, 96(10):586-595
|
[12] |
Inayoshi A, Hayashi S.Influence of Hydrogen on Reaction Behavior of Sinter Under a Blast Furnace Simulated Condition[J].Tetsu to Hagane, 2010, 96(10):586-595
|
[13] |
吴胜利, 韩宏亮, 许海法, 等.高炉内烧结矿与块矿高温交互反应机理研究[J][J].过程工程学报, 2010, 10(s1):37-42
|
[13] |
吴胜利, 韩宏亮, 许海法, 等.高炉内烧结矿与块矿高温交互反应机理研究[J][J].过程工程学报, 2010, 10(s1):37-42
|
[14] |
Verlag StahlEisen, Düsseldorf.Slag Atlas, 2nd ed [M], Germany, 1995, p. 126.
|
[14] |
Verlag StahlEisen, Düsseldorf.Slag Atlas, 2nd ed [M], Germany, 1995, p. 126.
|
[1] |
ZENG Zhi-hao1,ZOU Chong1,SHE Yuan1,2,YANG Jun1,MA Cheng1,HE Jiang-yong1. Effects of alkali metal enrichment on structure and gasification reactivity of blast furnace tuyere coke[J]. JOURNAL OF IRON AND STEEL RESEARCH , 2020, 32(6): 452-461. |
[2] |
LIU Ke, HAN Yi-hua, YANG Fan, ZHU Li-guang. Effect of MgO on microstructure of CaO-Al2O3 based quaternary system mold fluxes[J]. Iron and Steel, 2020, 55(5): 52-58. |
[3] |
NIU Lele,LIU Zhengjian,ZHANG Jianliang,ZHANG Zongwang, WANG Yaozu,DU Chengbo. Effect of mineral composition of iron ore on metallurgical properties of sinter[J]. Iron and Steel, 2019, 54(9): 27-32. |
[4] |
KANG Yi,ZOU Chong,ZHAO Jun-xue,HE Jiang-yong,MA Cheng,ZHANG Xiao-rui. Microstructure characteristics of semicoke under different pyrolysis processes and its influence on combustion performance[J]. JOURNAL OF IRON AND STEEL RESEARCH , 2019, 31(7): 601-611. |
[5] |
HAN Yue- xin,SUN Yong- sheng,LI Yan- feng,LI Yan- jun. Evolution law of phase and structure of oolitic hematite ore in coal- based reduction[J]. , 2019, 31(2): 95-102. |
[6] |
LIU Xin-liang, HONEYANDS Tom, O′DEA Damien, MITRA Subhasish, CHEN Jeff, QIU Guang-jun. Interaction between sinter and lump during softening and melting process[J]. Iron and Steel, 2019, 54(12): 19-26. |
|
|
|
|