锌对捣固焦和顶装焦气化反应的催化作用

王杰,王炜,徐润生,戴柏文,余岳,薛正良

钢铁研究学报 ›› 2017, Vol. 29 ›› Issue (9) : 732-738.

钢铁研究学报 ›› 2017, Vol. 29 ›› Issue (9) : 732-738. DOI: 10.13228/j.boyuan.issn1001- 0963.20160300
冶炼与加工

锌对捣固焦和顶装焦气化反应的催化作用

  • 王杰,王炜,徐润生,戴柏文,余岳,薛正良
作者信息 +

Catalysis behavior of zinc on gasification reaction of top charged coke and stamp charged coke

  • WANG Jie,WANG Wei,XU Run- sheng,DAI Bo- wen,YU Yue,XUE Zheng- liang
Author information +
文章历史 +

摘要

采用液相吸附法研究了不同温度、富锌量等条件对捣固焦和顶装焦气化反应的影响,并结合XRD、扫描电子显微镜和光学显微镜对比分析了锌对2种焦炭气化反应后的微晶结构、显微结构、孔结构的影响。研究结果表明,升高温度和增大富锌量均能使焦炭反应性增大,反应后焦炭强度减小。反应温度低于1000℃时,锌对焦炭气化反应的影响较小,而在1100℃时,2种焦炭的反应率随富锌浓度的增大快速增大,且富锌后顶装焦的反应率比捣固焦高约1%~2%。XRD分析表明,锌对焦炭有序化微晶气化反应的催化作用大于无序化微晶,从而导致气化反应后焦炭微晶片层的堆积高度减小,石墨化程度降低。结合扫描电子显微镜和光学显微全景图发现,锌在催化焦炭气化反应过程中孔壁变薄甚至消失,孔面积和孔直径增大,孔的贯穿连通程度加大,为锌蒸气的渗透和气化反应的动力学提供有利条件,导致反应进一步被加剧,但捣固焦较致密的孔结构使其在气化反应中具有优于顶装焦的抗锌催化能力。

Abstract

The influences of temperature and zinc content on the gasification reaction of top charged coke and stamp charged coke were investigated by liquid phase adsorption method. The effects of zinc on microcrystalline structure, microstructure, pore structure of two kinds of reacted coke were compared and analyzed by X- Ray diffraction (XRD), scanning electron microscopy (SEM) and optical microscopy. The results show that the gasification reaction can be enhanced by rising the reaction temperature or enriching zinc content, resulting in the increase of coke reactivity index and the decrease of coke strength after reaction. Furthermore, when the reaction temperature is lower than 1000℃, zinc has little effect on the gasification reaction. However, the reactivity of two kinds of coke increases rapidly with the increase of zinc content at 1100℃, and the reactivity of Zn- enriched top charged coke is about 1%-2% higher than that of Zn- enriched stamp charged coke. XRD analysis reveal that catalytic effect of zinc on gasification reaction of ordered microcrystals of coke is larger than that of the disordered microcrystals, and resulting in a decrease in the stacking height of crystallite, and a decrease in degree of graphitization of coke. The combination of SEM and optical panorama show that under the condition of catalysis effect of zinc on gasification reaction, pore walls become thinner even disappear, surface area and diameter of pores increase, as well as expansion and incorporation of coke pores enhance, which provides favorable conditions for the permeation of zinc vapor and the kinetics of gasification reaction, thereby the reaction is intensified. Moreover, the resistance to zinc catalysis on gasification reaction of stamp charged coke is better than that of top charged coke because of the dense pore structure of stamp charged coke.

关键词

捣固焦 / 顶装焦 / / 气化反应 / 催化作用

Key words

Stamp charged coke / top charged coke / zinc / gasification reaction / catalysis

引用本文

导出引用
王杰,王炜,徐润生,戴柏文,余岳,薛正良. 锌对捣固焦和顶装焦气化反应的催化作用[J]. 钢铁研究学报, 2017, 29(9): 732-738 https://doi.org/10.13228/j.boyuan.issn1001- 0963.20160300
WANG Jie,WANG Wei,XU Run- sheng,DAI Bo- wen,YU Yue,XUE Zheng- liang. Catalysis behavior of zinc on gasification reaction of top charged coke and stamp charged coke[J]. Journal of Iron and Steel Research, 2017, 29(9): 732-738 https://doi.org/10.13228/j.boyuan.issn1001- 0963.20160300

参考文献

[1] 潘登. 我国捣固炼焦技术的进步与发展方向[J]. 燃料与化工, 2013, 44(2): 1-2
[2] 史世庄, 雷耀辉, 曹素梅,等. 堆积密度对捣固炼焦焦炭性能的影响[J]. 武汉科技大学学报, 2011, 34(4): 285-288
[3] Pang Q H, Zhang J L, Qi C L, et al. K2CO3 catalysis on the reactivity of top charged coke and stamp charged coke [J]. International Journal of Minerals Metallurgy & Materials, 2013, 20(1): 17-27
[4] Chapman M W, Monaghan B J, Nightingale S A, et al. Observations of the Mineral Matter Material Present at the Coke/Iron Interface During Coke Dissolution into Iron[J]. Isij International, 2007, 47(7): 973-981
[5] And S M, Srivastava S K. Minerals Transformations in Northeastern Region Coals of India on Heat Treatment [J]. Energy & Fuels, 2006, 20(3): 1089-1096
[6] Li K, Khanna R, Zhang J, et al. The evolution of structural order, microstructure and mineral matter of metallurgical coke in a blast furnace: A review [J]. Fuel, 2014, 133(5): 194-215
[7] Zhong J B, Zhang J L, Li K J, et al. Catalytic Behavior of Potassium Vapor on Coke Gasification Reaction[J]. Steel Research International, 2016, 87: 1-7
[8] Longbottom R J, Monaghan B J, Chapman M W, et al. Techniques in the Study of Carbon Transfer in Ironmaking[J]. Steel Research International, 2011, 82(5): 505-511
[9] Monaghan B J, Chapman M W, Nightingale S A. Carbon Transfer in the Lower Zone of a Blast Furnace[J]. Steel Research International, 2010, 81(10): 829-833
[10] Ye Z Z, Gupta S, Kerkkonen O, et al. SiC and Ferro-silicides Formation in Tuyere Cokes[J]. Isij International, 2013, 53(1): 181-183
[11] Gupta S, Ye Z Z, Kanniala R, et al. Coke graphitization and degradation across the tuyere regions in a blast furnace[J]. Fuel, 2013, 113(113): 77-85
[12] Gupta S, Ye Z Z, Kim B C, et al. Mineralogy and reactivity of cokes in a working blast furnace[J]. Fuel Processing Technology, 2014, 117(1): 30-37
[13] Song Y U, Zhao H B, Cheng S S, et al. Influence of Alkali and Alkali-Chloride on Coke in the Blast Furnace[J]. Journal of Iron & Steel Research, 2011, 23(5): 20-23
[14] 赵宏博, 蔡皓宇, 程树森, 等. 钾、钠对焦炭劣化作用[J]. 北京科技大学学报, 2013, 35(4): 438-447
[15] Esezobor D E, Balogun S A. Zinc accumulation during recycling of iron oxide wastes in the blast furnace [J]. Ironmaking & Steelmaking, 2006, 33(5):419-425
[16] 穆林, 刘乐天, 郑海燕,等. 锌对焦炭反应性能的影响[J]. 钢铁, 2011, 46(8): 22-24
[17] 穆林, 刘乐天, 郑海燕,等. 锌对焦炭强度的影响[J]. 钢铁研究学报, 2011, 23(7): 10-13
[18] Li K, Zhang J, Liu Z, et al. Zinc Accumulation and Behavior in Tuyere Coke [J]. Metallurgical & Materials Transactions B, 2014, 45(5): 1581-1588
[19] 王喆, 张建良, 左海滨,等. 捣固焦高温气化反应特性[J]. 北京科技大学学报, 2014(12): 1602-1607
[20] 张慧轩. 铁焦气化反应机理的研究[D]. 武汉科技大学, 2015
[21] Xu R, Zhang J, Wang G, et al. Devolatilization Characteristics and Kinetic Analysis of Lump Coal from China COREX3000 Under High Temperature[J]. Metallurgical and Materials Transactions B, 2016, 47(8): 2535-2348
[22] 蔡皓宇, 程树森, 赵宏博,等. 碱金属对焦炭光学组织的影响[J]. 钢铁, 2013, 48(12): 9-15
[23] 王炜, 徐维波, 朱航宇,等. 高碱度烧结矿三位矿相特征分析[J]. 钢铁研究学报, Accept

基金

低品位烧结矿机理研究

82

Accesses

0

Citation

Detail

段落导航
相关文章

/