Abstract：The mixing time and circulation flow rate of RH with oval-shaped snorkel and round-shaped snorkel were investigated by water modeling. Compared with convention RH, under such conditions as 97709Pa of vacuum pressure and 130mm of insertion depth, the RH with oval-shaped snorkel shows obvious superiority of the circulation flow rate when gas flow is higher than 2.33m3/h. The mixing time is decreased obviously when gas flow is higher than 2.7m3/h. Change law of mixing time and circulation flow rate of RH with oval-shaped snorkel were measured at different parameters, and stream line experiment were done. It is found after analysis that mixing time and circulation flow rate of RH with oval-shaped snorkel is better with same flow rate per unit snorkel area. The circulation flow rate of RH can increase by 50% in experimental condition. At last the relationship of circulation flow rate between 2 models was established.
收稿日期: 2012-06-06
出版日期: 2013-02-27
引用本文:
贺庆，刘浏，李相臣，薛利强. 浸渍管形状对RH精炼中钢液流动和混合特性的影响[J]. 钢铁, 2013, 48(2): 13-28.
HE Qing,LIU Liu,LI Xiang-chen,XUE Li-qiang. Influence of Snorkel Shape on Characteristics of Flow and Mixing of RH. Iron and Steel, 2013, 48(2): 13-28.
Tatsuro KUWABARA,Kazusige UMEZAWA,Kouji MORI and Hisashi WATANABE.Investigation of decarburization behavior in RH-reactor and its operation improvement[J].Transactions ISIJ,1988,28(4):305-314
[8]
Tatsuro KUWABARA,Kazusige UMEZAWA,Kouji MORI and Hisashi WATANABE.Investigation of decarburization behavior in RH-reactor and its operation improvement[J].Transactions ISIJ,1988,28(4):305-314
[9]
VSESHADRI and S.LUIZ..Cold model studies of R.H. degassing process[J].Transactions ISIJ,1986,26(2):133-138
[9]
VSESHADRI and S.LUIZ..Cold model studies of R.H. degassing process[J].Transactions ISIJ,1986,26(2):133-138
2013, Vol. 48 
