低质焦炭下高炉炉尘及喷吹煤粉利用率

doi:10.13228/j.boyuan.issn0449-749x.20150041

摘要
图/表
参考文献
相关文章 (0)

全文: PDF (0 KB) HTML (0 KB)
输出: BibTeX | EndNote (RIS)

摘要为了研究低质焦炭条件下高炉喷吹煤粉的利用率，对安钢高炉两批低质焦炭及炉尘进行取样分析。测定了焦炭的常用质量评价指标及炉顶除尘灰的碳质量分数，并采用岩相测试技术分析了炉尘未消耗煤粉和焦炭的不同结构形态，定量地给出了炉尘中未消耗煤粉和焦炭颗粒的质量分数。结合安钢配煤现状，考察了3种高炉所用喷吹原煤不同粒径的燃烧率，并讨论了不同烟煤配比下挥发分质量分数对不同粒径煤粉燃烧率的影响，为低质焦炭条件下提高煤粉利用率提出合理化建议。结果表明，低质焦炭条件下，炉尘碳质量分数明显偏高并含有较多未消耗煤粉；炉尘中的未消耗煤粉分为热变煤颗粒和残炭颗粒，而未消耗焦炭则以镶嵌结构为主；控制焦炭质量波动、减少焦炭水分质量分数有利于降低炉尘碳质量分数；安钢喷煤首选无烟煤应为B煤，喷吹煤粉的挥发分适宜控制在17%左右。

	服务

	把本文推荐给朋友
	加入我的书架
	加入引用管理器
	E-mail Alert
	RSS
	作者相关文章
	闫广
	吴铿
	刘肖
	门正朝
	申威
	员晓

关键词 ：低质焦炭, 高炉炉尘, 煤粉利用率, 优化配煤

Abstract：In order to investigate the effects of low-quality coke on utilization rate of pulverized coal into BF of Anyang Steel， two batches of charging coke and BF dust were analyzed. The quality of coke and carbon content of BF dust were measured. Since the petrographical microstructure of unconsumed pulverized coal and coke in dust were different， the amount of coal and coke could be quantitated via lithofacies analysis. Based on the present coal blending situation， the combustion rate of three pulverized coals was examined. Effects of volatile on combustion rate of pulverized coal with different particle size were researched， which could provide an effective guidance to improve the utilization rate of pulverized coal in low-quality coke situation. The results show that the carbon content and UPC (unconsumed pulverized coal) in BF dust are comparatively high. The UPC in the dust is made up of thermally altered coal and residual carbon particles while the unconsumed coke is mainly composed of mosaic structure. Keeping the coke quality steady and low moisture content could contribute to the decrease of carbon content of BF dust. It’s suggested that coal B should be the first selected anthracite and the volatile of pulverized coal should be controlled at around 17%.

Key words： low-quality coke BF dust utilization rate of pulverized coal optimized coal blending

收稿日期: 2015-01-21 出版日期: 2015-12-03

引用本文:

闫广，吴铿，刘肖，门正朝，申威，员晓. 低质焦炭下高炉炉尘及喷吹煤粉利用率[J]. 钢铁, 2015, 50(12): 85-90. YAN Guang，WU Keng，LIU Xiao，MEN Zheng-chao，SHEN Wei，YUN Xiao. Dust and utilization rate of pulverized coal injection into BF in low-quality coke situation. Iron and Steel, 2015, 50(12): 85-90.

链接本文:

http://www.chinamet.cn/Jweb_gt/CN/10.13228/j.boyuan.issn0449-749x.20150041 或 http://www.chinamet.cn/Jweb_gt/CN/Y2015/V50/I12/85

[1]	Antoine GS, Edwin ES, Toxopeus H, etal. High injection rates of coal into the blast furnace [J].MPT, 1994, 17(3): 58-60.
[1]	Antoine GS, Edwin ES, Toxopeus H, etal. High injection rates of coal into the blast furnace [J].MPT, 1994, 17(3): 58-60.
[2]	Sengupta I, KumarA, Ghosh S, etal. Blast furnace efficiency enhancer for pulverized coal injection [J]. AISE Steel Technology(USA), 2000, 77(2): 61-62.
[2]	Sengupta I, KumarA, Ghosh S, etal. Blast furnace efficiency enhancer for pulverized coal injection [J]. AISE Steel Technology(USA), 2000, 77(2): 61-62.
[3]	Iwanaga YJ. Investigation on behavior of unburnt pulverized coal in blast furnace [J]. ISIJ International, 1991,31(5): 494-499.
[3]	Iwanaga YJ. Investigation on behavior of unburnt pulverized coal in blast furnace [J]. ISIJ International, 1991,31(5): 494-499.
[4]	刘新，陈星秋. 未燃煤粉在高炉内的分布特性的实验研究[J]. 东北大学学报， 2000, 21(2): 177-180.
[4]	刘新，陈星秋. 未燃煤粉在高炉内的分布特性的实验研究[J]. 东北大学学报， 2000, 21(2): 177-180.
[5]	郭豪，张建良，张雪松，等. 未燃煤粉对高炉终渣性能的影响[J]. 过程工程学报， 2008, 6(8): 280-283.
[5]	郭豪，张建良，张雪松，等. 未燃煤粉对高炉终渣性能的影响[J]. 过程工程学报， 2008, 6(8): 280-283.
[6]	郑涛，吴铿，徐万仁，等. 高炉炉尘中未消耗煤粉和焦炭比例的研究[J]. 钢铁， 2006, 41(3): 20-24.
[6]	郑涛，吴铿，徐万仁，等. 高炉炉尘中未消耗煤粉和焦炭比例的研究[J]. 钢铁， 2006, 41(3): 20-24.
[7]	孟庆波，张孝天. 高炉喷煤对焦炭质量的要求及改善焦炭质量的途径[J]. 炼铁， 2000, 19(6): 23-26.
[7]	孟庆波，张孝天. 高炉喷煤对焦炭质量的要求及改善焦炭质量的途径[J]. 炼铁， 2000, 19(6): 23-26.
[8]	王文泽，湛文龙，刘肖，等. 高炉入炉焦炭高温反应特性研究[J]. 有色金属科学与工程， 2014, 5(1): 9-13.
[8]	王文泽，湛文龙，刘肖，等. 高炉入炉焦炭高温反应特性研究[J]. 有色金属科学与工程， 2014, 5(1): 9-13.
[9]	丁汝才，吴铿，吴玮璐，等. 首秦1号高炉不同喷煤比条件下炉尘灰中含碳物质的研究[J]. 煤炭学报， 2008, 33(11): 1301-1304.
[9]	丁汝才，吴铿，吴玮璐，等. 首秦1号高炉不同喷煤比条件下炉尘灰中含碳物质的研究[J]. 煤炭学报， 2008, 33(11): 1301-1304.
[10]	张飞，吴铿，朱锦明，等. 高炉炉尘中含碳物质的来源[J]. 北京科技大学学报， 2006, 28(6): 559-565.
[10]	张飞，吴铿，朱锦明，等. 高炉炉尘中含碳物质的来源[J]. 北京科技大学学报， 2006, 28(6): 559-565.
[11]	夏柱海，吴铿，朱锦明，等. 高炉喷吹常村煤时煤粉的利用率[J]. 北京科技大学学报， 2006, 28 (7): 676-680.
[11]	夏柱海，吴铿，朱锦明，等. 高炉喷吹常村煤时煤粉的利用率[J]. 北京科技大学学报， 2006, 28 (7): 676-680.
[12]	吴铿，陈洪飞，徐万仁，等. 高喷煤比时高炉炉尘灰中含碳物质研究[J]. 北京科技大学学报， 2008, 30 (6): 664-668.
[12]	吴铿，陈洪飞，徐万仁，等. 高喷煤比时高炉炉尘灰中含碳物质研究[J]. 北京科技大学学报， 2008, 30 (6): 664-668.