中关铁矿制备熔剂性球团生球性能试验

doi:10.13228/j.boyuan.issn0449-749x.20220458

摘要
图/表
参考文献
相关文章 (15)

全文: PDF (2296 KB) HTML (1 KB)
输出: BibTeX | EndNote (RIS)

摘要通过增加熔剂性球团矿的入炉比例,能够改善炉料结构,降低炼铁系统能耗,并且通过“源头减量”的途径可以降低炼铁过程中污染物的排放。实现高球比冶炼的核心环节是制备熔剂性球团,而熔剂性球团质量取决于生球的性能,因此,保证生球质量是探究熔剂性球团制备工艺较为重要的环节。由于中关铁矿硅含量较低、镁含量适宜,适合作为低硅熔剂性球团的原料。以中关铁矿为原料探究熔剂性球团的制备工艺,并在此基础上分析了影响熔剂性球团生球质量的因素(粒度、时间、水分、膨润土、SiO₂含量、碱度和MgO含量)。试验结果表明,生球的抗压强度、落下强度及爆裂温度受碱度、SiO₂和MgO含量变化的影响不大;生球的抗压强度、落下强度及爆裂温度主要受造球时间、水分、黏结剂用量、铁矿粉及熔剂的理化性能影响,并在造球时间维持为12 min、水分维持为8%～9%、膨润土用量为2%时,生球抗压强度、落下强度及爆裂温度较优且满足运输与入炉要求。

	服务

	把本文推荐给朋友
	加入我的书架
	加入引用管理器
	E-mail Alert
	RSS
	作者相关文章
	罗林根
	庞建明
	宋耀欣
	师学峰
	陈泽宇
	胡启晨

关键词 ：熔剂性球团, 球团工艺, 抗压强度, 落下强度, 爆裂温度

Abstract：By increasing the proportion of molten pellets into the furnace, the structure of the furnace charge is improved, the energy consumption of the ironmaking system is reduced, and the emission of pollutants in the ironmaking process is reduced through the "source reduction" approach. The core link to achieve high pellet ratio smelting is to prepare flux pellets, and the quality of flux pellets depends on the performance of raw balls, so ensuring the quality of raw balls is an important part of exploring the preparation process of flux pellets. Due to the low silicon content and suitable magnesium content of Zhongguan iron ore, which is suitable as the raw material for low silicon flux pellets, Zhongguan iron ore was used as raw material to explore the preparation process of flux pellets, and on this basis, the factors affecting the quality of flux pellets (particle size, time, moisture, bentonite, SiO₂ content, alkalinity and MgO content) are analyzed. The test results show that the compressive strength, falling strength and bursting temperature of raw pellets are not greatly affected by the changes of alkalinity, SiO₂ and MgO content. The compressive strength, falling strength and bursting temperature of raw pellets are mainly affected by the pellet making time, moisture, binder dosage, physicochemical properties of iron ore powder and melt, and the compressive strength, falling strength and bursting temperature of raw pellets are better and meet the transportation and furnace requirements when the pellet making time is maintained at 12 min, moisture is maintained between 8% and 9%, and bentonite dosage is 2%.

Key words： fusible pellet pellet process compressive strength drop strength bursting temperature

收稿日期: 2022-07-01

引用本文:

罗林根, 庞建明, 宋耀欣, 师学峰, 陈泽宇, 胡启晨. 中关铁矿制备熔剂性球团生球性能试验[J]. 钢铁, 2022, 57(12): 32-40. LUO Lin-gen, PANG Jian-ming, SONG Yao-xin, SHI Xue-feng, CHEN Ze-yu, HU Qi-chen. Experiment on cold performance of fluxed pellets prepared from Zhongguan iron ore powder[J]. Iron and Steel, 2022, 57(12): 32-40.

链接本文:

http://www.chinamet.cn/Jweb_gt/CN/10.13228/j.boyuan.issn0449-749x.20220458 或 http://www.chinamet.cn/Jweb_gt/CN/Y2022/V57/I12/32

[1] 潘向阳. MgO的配分对高炉综合炉料冶金性能的影响[D]. 唐山:华北理工大学, 2019.(PAN Xiang-yang. The Influence of MgO Distribution on the Metallurgical Properties of Blast Furnace Comprehensive Charge[D]. Tangshan: North China University of Technology, 2019.)
[2] 王新东, 金永龙.高炉使用高比例球团的战略思考与球团生产的试验研究[J]. 钢铁, 2021, 56(5):7.(WANG Xin-dong, JIN Yong-long. Strategy analysis andtesting study of high ratio of pellet utilized in blast furnace[J].Iron and Steel, 2021, 56(5):7.)
[3] 王新东, 李建新, 胡启晨.基于高炉炉料结构优化的源头减排技术及应用[J]. 钢铁, 2019, 54(12):104.(WANG Xin-dong, LI Jian-xin, HU Qi-chen. Application practice of source and process sulfur-nitrate reduction technology based on optimization of blast furnace charge structure[J]. Iron and Steel, 2019, 54(12):104.)
[4] 赵宏博, 刘原, 许满兴, 等. 球团矿优化配料方法及应用研究[J]. 烧结球团, 2018, 43(4):40.(ZHAO Hong-bo, LIU Yuan, XU Man-xing, et al. Research on optimization method and application of pelletizing batching[J]. Sintered and Pelletizing, 2018, 43(4):40.)
[5] 汪书朝, 师学峰, 张巧荣, 等. 镁质球团矿焙烧固结及其机理研究[J]. 钢铁钒钛, 2018, 39(5):79.(WANG Shu-chao, SHI Xue-feng, ZHANG Qiao-rong, et al. Roasting and consolidation of magnesia pellets and its mechanism[J]. Steel Vanadium and Titanium, 2018, 39(5):79.)
[6] 邓睿.带式焙烧机制备镁质熔剂性球团研究[J]. 中国冶金, 2021, 31(2):55.(DENG Rui.Study on magnesia-bearing fluxed pellets production by travelling grate[J].China Metallurgy, 2021,31(2):55.)
[7] 高冰, 魏焕君, 李晓云, 等.镁质熔剂性球团回转窑结圈探析[J].中国冶金, 2018, 28(4):17.(GAO Bing, WEI Huan-jun, LI Xiao-yun, et al. Analysis of magnesia flux pellet rotary kiln ring formation[J]. China Metallurgy, 2018, 28(4):17.)
[8] 潘向阳, 龙跃, 李神子, 等. w(MgO)对熔剂性球团矿冶金性能的影响[J]. 钢铁, 2019, 54(10):17.(PANG Xiang-yang, LONG Yue, LI Shen-zi, et al.Effect of w(MgO) on metallurgical properties of flux pellets[J].Iron and Steel, 2019, 54(10):17.)
[9] 邢宏伟, 刘振超, 程菲雨, 等.基于微观技术的镁质熔剂性球团矿相研究[J]. 矿产综合利用, 2019(2):148.(XING Hong-wei, LIU Zhen-chao, CHEN Fei-yu, et al. Study on the mineralogy of magnesia flux pellets based on microscopic technology[J]. Multipurpose Utilization of Mineral Resources,2019(2):148.)
[10] 薄胜岳, 胡长庆, 师学峰, 等.镁质熔剂性球团矿发展现状及展望[J]. 华北理工大学学报(自然科学版), 2021, 43(3):40.(BO Sheng-yue, HU Chang-qing, SHI Xue-feng, et al. Development status and prospect of magnesia flux pellets[J]. Journal of North China University of Technology (Natural Science), 2021, 43(3):40.)
[11] 张汉泉. 烧结球团理论与工艺[M]. 北京:化学工业出版社, 2018.(ZHANG Han-quan. Theory and Technology of Sintered Pellets[M]. Beijing: Chemical Industry Press, 2018.)
[12] 刘卫星, 李杰, 杨爱民, 等.碱度对镁质熔剂性球团矿强度的影响机理[J]. 钢铁, 2021, 56(1):28.(LIU Wei-xing, LI Jie, YANG Ai-min,et al. Influence mechanism of basicity on strength of magnesium fluxed pellets[J].Iron and Steel, 2021, 56(1):28.)
[13] 田铁磊, 师学峰, 蔡爽, 等.镁质熔剂性球团孔结构特性[J]. 钢铁, 2016, 51(10):10.(TIAN Tie-lei, SHI Xue-feng, CAI Shuang, et al. Pore structure characteristics of magnesian flux pellets[J].Iron and Steel, 2016, 51(10):10.)
[14] 陈朝中. 膨润土对铁精矿成球性能的影响[J]. 烧结球团, 1984(4):36.(CHEN Chao-zhong. The influence of bentonite on the spheroidizing properties of iron concentrate[J]. Sintered Pellets, 1984(4):36.)
[15] 王晓磊, 师学峰, 胡长庆, 等. 高硅镁质熔剂性球团成球过程及冷态性能实验[J]. 钢铁研究学报, 2020, 32(3):212.(WANG Xiao-lei, SHI Xue-feng, HU Chang-qing, et al. Pelletization process and cold performance experiment of high silicon magnesia flux pellets[J]. Journal of Iron and Steel Research, 2020, 32(3):212.)
[16] 张林林, 付刚华, 郭宇峰, 等.碱度对熔剂性球团生球性能的影响[J]. 钢铁, 2019, 54(5):14.(ZHANG Lin-lin, FU Gang-hua, GUO Yu-feng, et al. The effect of alkalinity on the properties of flux-based pellets[J]. Iron and Steel, 2019, 54(5):14.)
[17] 李杰, 信自成, 杨爱民, 等. 碱度对镁质熔剂性球团性能的影响[J]. 钢铁, 2017, 52(7):35.(LI Jie, XIN Zi-cheng,YANG Ai-min, et al. The effect of alkalinity on the properties of magnesia flux pellets[J]. Iron and Steel, 2017, 52(7):35.)
[18] 高强健, MgO基球团添加剂制备及对球团矿质量影响的机理研究[D]. 沈阳:东北大学, 2014.(GAO Qiang-jian. Preparation of MgO-based Pellet Additives and the Mechanism Study on the Impact on Pellet Quality[D]. Shenyang: Northeastern University, 2014.)
[19] 王晓磊, 师学峰, 胡长庆, 等. 高硅镁质熔剂性球团焙烧试验研究[J]. 矿产综合利用, 2020(4):87.(WANG Xiao-lei, SHI Xue-feng, HU Chang-qing, et al. Experimental research on roasting of high-silica magnesia flux pellets[J]. Comprehensive Utilization of Mineral Resources, 2020(4):87.)
[20] 臧疆文, 王梅菊.生球爆裂温度的影响因素及提高途径[J]. 新疆钢铁, 2004, 4(3):13.(ZANG Jiang-wen, WANG Mei-ju. Influencing factors and ways to increase the burst temperature of the green ball[J]. Xinjiang Iron and Steel, 2004, 4(3):13.)
[21] 张国成, 罗果萍, 邬虎林, 等. 配加蒙古精矿对球团矿性能的影响[J]. 中国冶金, 2019, 29(11):24.(ZHANG Guo-cheng, LUO Guo-ping, WU Hu-lin, et al. Effects of adding Mongolian concertrate on pellets properties[J]. China Metallurgy, 2019, 29(11):24.)
[22] 于洪军, 路明, 王兴锋, 等. 铁矿粉粒度组成对球团矿性能影响的研究进展[J]. 冶金能源, 2022, 41(1):21.(YU Hong-jun, LU Ming, WANG Xing-feng, et al. Research progress on the effect of iron fine particle size on pellet properties[J]. Energy for Metallurgical Industry, 2022, 41(1):21.)