LF精炼渣对镁碳质基片的润湿性和渗透性

doi:10.13228/j.boyuan.issn0449-749x.20160128

Abstract
Figure/Table
References
Related Citation (15)

Download: PDF (0 KB) HTML (0 KB)
Export: BibTeX | EndNote (RIS)

Abstract In order to investigate the wear mechanism of MgO-C brick from the point of wettability， the sessile drop method was employed to measure the contact angle between liquid and solid phase. The wettability between MgO-C substrate as well as two main components in the substrate and LF refining slag was studied. At the refining temperature， graphite substrate was not wetted by the molten slag， and the lower temperature it was， the more non-wetting it became. While the MgO component was completely wetted by the slag. There was an obvious turning point of contact angle between molten slag and MgO-C substrate in the range of 1 460 ℃ and 1 480 ℃. Below the turning point， the reaction between MgO and C was restrained for the lower temperature， and the MgO-C substrate kept un-wetted by molten slag. Above the turning point， the MgO reacted with carbon， and Mg vapor and CO gas were generated. The carbon content was reduced for the reaction， leading to the fast decrease of contact angle between molten slag and substrate. Once the contact angle was smaller than 90°， the molten slag penetrated into the substrate. The pores formed by the reaction between MgO and carbon became the main channel for the penetration of slag. When the slag penetrated into the substrate and reached at the interface of unreacted layer， the non-wetting property between the slag and unreacted layer and few pores prevented the further penetration of slag.

Received: 05 April 2016 Published: 09 December 2016

PACS:

TF769.2

	Service

	E-mail this article
	Add to my bookshelf
	Add to citation manager
	E-mail Alert
	RSS
	Articles by authors
	CHEN Beng
	ZHANG Li-Feng
	YANG Wen
	YU Yi

Cite this article:

CHEN Beng,ZHANG Li-Feng,YANG Wen等. Wettability and penetration phenomenon between LF refining slag and MgO-C substrate[J]. Iron and Steel, 2016, 51(12): 31-40.

URL:

http://www.chinamet.cn/Jweb_gt/EN/10.13228/j.boyuan.issn0449-749x.20160128 OR http://www.chinamet.cn/Jweb_gt/EN/Y2016/V51/I12/31

[1]	李亮, 王世峰, 陈士冰.镁碳砖发展及生产工艺改进的研究[J].山东轻工业学院学报自然科学版, 2010, 24(3):25-28
[1]	李亮, 王世峰, 陈士冰.镁碳砖发展及生产工艺改进的研究[J].山东轻工业学院学报自然科学版, 2010, 24(3):25-28
[2]	Hashemi B, Nemati Z A, Faghihi-Sani M A.Effects of resin and graphite content on density and oxidation behavior of MgO-C refractory bricks[J].Ceramics International, 2006, 32(3):313-319
[2]	Hashemi B, Nemati Z A, Faghihi-Sani M A.Effects of resin and graphite content on density and oxidation behavior of MgO-C refractory bricks[J].Ceramics International, 2006, 32(3):313-319
[3]	魏耀武, 徐静波, 徐烜, 等.精炼钢包渣线镁碳砖被侵蚀的显微分析[J].硅酸盐通报, 2009, 28(1):185-188
[3]	魏耀武, 徐静波, 徐烜, 等.精炼钢包渣线镁碳砖被侵蚀的显微分析[J].硅酸盐通报, 2009, 28(1):185-188
[4]	李培, 田琳.不同碳含量对镁碳砖性能的影响[J].耐火与石灰, 2012, 37(1):7-9
[4]	李培, 田琳.不同碳含量对镁碳砖性能的影响[J].耐火与石灰, 2012, 37(1):7-9
[5]	呼伟, 尹洪峰, 史绪波, 等.不同基质结合镁碳砖对炉渣的抗侵蚀性研究[J].硅酸盐通报, 2011, 30(1):200-204
[5]	呼伟, 尹洪峰, 史绪波, 等.不同基质结合镁碳砖对炉渣的抗侵蚀性研究[J].硅酸盐通报, 2011, 30(1):200-204
[6]	Guo M, Parada S, Jones P T, et al.Interaction of Al2O3-rich slag with MgO-C refractories during VOD refining—MgO and spinel layer formation at the slagrefractory interface[J].Journal of the European Ceramic Society, 2009, 29(6):1053-1060
[6]	Guo M, Parada S, Jones P T, et al.Interaction of Al2O3-rich slag with MgO-C refractories during VOD refining—MgO and spinel layer formation at the slagrefractory interface[J].Journal of the European Ceramic Society, 2009, 29(6):1053-1060
[7]	Yuan Z, Wu Y, Zhao H, et al.Wettability between molten slag and MgO–C refractories for the slag splashing process[J].ISIJ International, 2013, 53(4):598-602
[7]	Yuan Z, Wu Y, Zhao H, et al.Wettability between molten slag and MgO–C refractories for the slag splashing process[J].ISIJ International, 2013, 53(4):598-602
[8]	杜景云, 马北越, 聂立诚, 等.钢水温度和碳对镁铝尖晶石质耐火材料侵蚀的影响[J].中国冶金, 2007, 17(12):32-36
[8]	杜景云, 马北越, 聂立诚, 等.钢水温度和碳对镁铝尖晶石质耐火材料侵蚀的影响[J].中国冶金, 2007, 17(12):32-36
[9]	Abdeyazdan H, Monaghan B J, Dogan N, et al.The effect of slag basicity on spinel inclusion wettability[C]. Faculty of Engineering and Information Sciences - Papers. Melbourne, 2013: 44-47.
[9]	Abdeyazdan H, Monaghan B J, Dogan N, et al.The effect of slag basicity on spinel inclusion wettability[C]. Faculty of Engineering and Information Sciences - Papers. Melbourne, 2013: 44-47.
[10]	施月循, 厉英, 王文忠.含钛碳质复合耐火材料与渣铁润湿性的研究[J].钢铁研究学报, 1992, 4(4):65-70
[10]	施月循, 厉英, 王文忠.含钛碳质复合耐火材料与渣铁润湿性的研究[J].钢铁研究学报, 1992, 4(4):65-70
[11]	Eustathopoulos N, Nicholas M G, Drevet B.Wettability at high temperatures[M]. Pergamon: Elsevier, 1999.
[11]	Eustathopoulos N, Nicholas M G, Drevet B.Wettability at high temperatures[M]. Pergamon: Elsevier, 1999.
[12]	Cassie A B D, Baxter S.Wettability of porous surfaces[J][J].Transactions of the Faraday Society, 1944, 40:546-551
[12]	Cassie A B D, Baxter S.Wettability of porous surfaces[J][J].Transactions of the Faraday Society, 1944, 40:546-551
[13]	Cassie A B D.Contact angles[J].Discuss Faraday Soc, 1948, 3(5):11-16
[13]	Cassie A B D.Contact angles[J].Discuss Faraday Soc, 1948, 3(5):11-16
[14]	Heo S H, Lee K, Chung Y.Reactive wetting phenomena of MgO-C refractories in contact with CaO-SiO2 slag[J].Transactions of Nonferrous Metals Society of China, 2012, 22(35):870-875
[14]	Heo S H, Lee K, Chung Y.Reactive wetting phenomena of MgO-C refractories in contact with CaO-SiO2 slag[J].Transactions of Nonferrous Metals Society of China, 2012, 22(35):870-875
[15]	Abdeyazdan H, Dogan N, Rhamdhani M A, et al.Dynamic wetting of CaO-Al2O3-SiO2-MgO liquid oxide on MgAl2O4 spinel[J].Metallurgical and Materials Transactions B, 2014, 46(B):208-219
[15]	Abdeyazdan H, Dogan N, Rhamdhani M A, et al.Dynamic wetting of CaO-Al2O3-SiO2-MgO liquid oxide on MgAl2O4 spinel[J].Metallurgical and Materials Transactions B, 2014, 46(B):208-219
[16]	王恩泽, 王恩万, 邢建东, 等.涂层对氧化铝耐热钢液间湿润角的影响及其应用[J].西安交通大学学报, 2000, 34(11):78-81
[16]	王恩泽, 王恩万, 邢建东, 等.涂层对氧化铝耐热钢液间湿润角的影响及其应用[J].西安交通大学学报, 2000, 34(11):78-81
[17]	Delannay F, Froyen L, Deruyttere A.The wetting of solids by molten metals and its relation to the preparation of metal-matrix composites[J].Journal of Materials Science, 1986, 22(1):1-16
[17]	Delannay F, Froyen L, Deruyttere A.The wetting of solids by molten metals and its relation to the preparation of metal-matrix composites[J].Journal of Materials Science, 1986, 22(1):1-16
[18]	Amin? M, Kazemzadehz A, Arfaei B, et al.Investigations of calcium aluminate slag penetration to MgO monolithic refractories in steelmaking process[J].International Journal of ISSI, 2006, 3(2):34-42
[18]	Amin? M, Kazemzadehz A, Arfaei B, et al.Investigations of calcium aluminate slag penetration to MgO monolithic refractories in steelmaking process[J].International Journal of ISSI, 2006, 3(2):34-42
[19]	陈肇友.炉外精炼用耐火材料提高寿命的途径及其发展动向[J].耐火材料, 2007, 41(1):1-12
[19]	陈肇友.炉外精炼用耐火材料提高寿命的途径及其发展动向[J].耐火材料, 2007, 41(1):1-12
[20]	敖进清, 李楠, 韩兵强.含钒钢渣对镁碳砖的侵蚀[J].耐火材料, 2006, 40(4):287-290
[20]	敖进清, 李楠, 韩兵强.含钒钢渣对镁碳砖的侵蚀[J].耐火材料, 2006, 40(4):287-290
[21]	陈康华, 包崇玺.金属陶瓷润湿性上[J].材料科学与工程, 1997, 15(3):6-10
[21]	陈康华, 包崇玺.金属陶瓷润湿性上[J].材料科学与工程, 1997, 15(3):6-10